Log Splitter purchased online can be serviced and repaired under warranty,
just like those from local dealers and retailers.
The log splitters found here at cnsuperpower.com come with at least a
1-year manufacturer warranty, meaning that anything covered under warranty can
be repaired at any authorized service center.
There are just a few basic components to a hydraulic log splitter. These are,
in addition to the steel frame and wheels for ease of moving, a hydraulic
cylinder, an oil pump, a control valve and a gas powered engine. Tools and
materials may vary depending on what is wrong with the splitter, but in general,
it’s good to have a few basic items on hand.
Step 1: Troubleshoot – Oil Pump
Knowing precisely what is wrong with your log splitter is the first step to
repair. If you keep enough hydraulic fluid in the reserve tank, the oil pump
should be in good working order. You may need to replace the oil filter if it is
old and worn out. Additionally, the hosing that channels the high-pressure and
low-pressure fluid to and from the cylinder might need replacing.
Step 2: Engine
Check the engine. Make sure there is both fuel and fire getting to the motor.
If it’s not starting, check the spark plug. If you can look into the carburetor
and see gas, fuel is getting there. If it is, it’s probably not getting fire.
The plug and points wear out after time and will need replacing. Pull the plug
wire off and with insulated pliers, hold it about ¼-inch from the tip of the
plug and pull the rope starter. If no spark is seen, the points need
replacing.
Step 3: Hydraulic Cylinder
Assuming the cylinder is not severely damaged, that is, has not swelled,
cracked, and the piston rod is not damaged, a faulty seal or piston ring inside
the cylinder is usually to blame. To replace the seal, you may have to dismantle
the whole cylinder. Never use a sharp object to remove the seal, and be careful
not to scratch the shaft or you could have problems later. Obtain a diagram of
the cylinder if you do not already have one for specific instructions on
dismantling it.
Step 4: Valve
The valve is the switch you use to control the pressure into and out of the
cylinder. It is the control that applies force to the cylinder which in turn
pushes the log onto the splitting wedge. Check to see that the valve is
operating properly. Making sure the hosing is not damaged and that the seals are
all tight will go a long way in letting you know what’s wrong.
Both a horizontal and a vertical log splitter can be gas powered hydraulic
machines. There are only a few parts to a hydraulic log splitter, making it one
of the simplest hydraulic tools in use. Troubleshooting possible malfunctions
involves checking each of the component parts: valve, oil pump, engine, and
hydraulic cylinder and all of the connecting seals and hosing. Once isolated,
you can focus on the specific component and get your Performance Built Log Splitter working
properly again.
2017年3月31日星期五
2017年3月30日星期四
Here’s what the best Forest King Log Splitter for most people needed to have
At Cnsuperpower, we have a variety of high quality log splitter for sale.
It took us over 60 hours of extensive testing to find the best Log Splitter for most people. We rated their speed, force and ease of use, as well as how well did they handle different types of wood, from lightweight to hard categories, both wet and dry, knotted and clean.After many weeks of thorough research, we picked 10 different models and created a checklist which contained characteristics we determined to be essential for the best log splitter.
Here’s what the best log splitter for most people needed to have:
Strength. One of the main reasons people think about switching to a log splitter is their power, so one of the main factors in our decision was the strength of the motor and splitting force, as well as the ability of log splitter to handle a variety of wood types and sizes.
Speed. Another important feature of log splitters is the fact the significantly reduce time needed for cutting wood. We rated log splitters for their cycle time, or more precisely, the average time needed for different models to split the same log.
Economy. Power-hungry machines tend to do work great, but at a great cost too. We tried to find log splitter that offers optimal balance between quality performance and economical consumption of power.
Ease of use. Log splitters use different modes of operation, and some of them proved to be easier to handle, therefore, more suitable for a wide variety of people to use.
Mobility. Although not all people look for a log splitter that can be easily moved, it’s certainly a benefit to have the option to use a log splitter on various sites, depending on the situation that comes up. Lightweight models or cordless log splitters hold an advantage in this part of testing, due to the fact they are more easily moved if needed.
Additional features. Some models have additional useful features, like changeable position, automatic ram return or attachment for towing, so we considered that when we rated Forest King Log Splitter. Additional features could really elevate a log splitter to a whole another level, so models who had useful features were awarded with bonus points.
2017年3月27日星期一
Forest King Log Splitter with a gas cnsuperpower log splitter
Forest King Log Splitter with a gas cnsuperpower log splitter doesn't have to require a lot of
muscle.
With the right techniques and the right tools, any David can conquer a Goliath-sized log.
So before you go trying to hack a tree into firewood, consider these tips, tricks, and tools to help you succeed.
After all, nobody - big or small - wants to end their day with a hernia.
Cutting Down to Size
You've gotta crawl before you walk, right?
The same goes here. Before you split into smaller pieces, you'll have to cut the monstrous log into halves.
Using a horizontal/vertical cnsuperpower log splitter allows you to pivot into a vertical position and roll (or "walk") the log into place without lifting.
Catch the Break
Once you've gotten that big bad thing split down by half, you may be able to lift it onto the splitter.
Once you're able to lift it onto the splitter, you can cut that half into quarters, but the pieces may still be too large to catch as they're cut.
Log cradles can help catch the halves as they're split, so that way you're not continuously bending and lifting the pieces.
This is a good thing, because a quarter of a giant log still needs to be split further.
Working in Double-Time
If you've got a lot of medium-sized logs that need to be split into quarters, you may not want to spend as much time on each one.
To power through many logs in half the time, you can use a 4-way wedge to cut your work load in half. Essentially, it combines the previous two steps into one by incorporating wings on the splitting wedge to cut it into 4 pieces at once.
While this won't necessarily be the way to go with super-sized logs, it'll cut your workload in half with the average sized logs.
Jiashan Superpower Tools Co., Ltd specializes in manufacturing various kinds of Lawn & Garden products and log splitters. Our main items are bg splitter, dump carts, spreaders, lawn sweepers, lawn aerators , etc. Over ten years of manufacturing experience in log splitter industry, we developed more and more innovative log splitter , which are energy-saving and environmentally friendly. We have got a few patents on some of our Log Splitter.Su-perpower has become a leading manufacturer in log splitters in China.
With the right techniques and the right tools, any David can conquer a Goliath-sized log.
So before you go trying to hack a tree into firewood, consider these tips, tricks, and tools to help you succeed.
After all, nobody - big or small - wants to end their day with a hernia.
Cutting Down to Size
You've gotta crawl before you walk, right?
The same goes here. Before you split into smaller pieces, you'll have to cut the monstrous log into halves.
Using a horizontal/vertical cnsuperpower log splitter allows you to pivot into a vertical position and roll (or "walk") the log into place without lifting.
Catch the Break
Once you've gotten that big bad thing split down by half, you may be able to lift it onto the splitter.
Once you're able to lift it onto the splitter, you can cut that half into quarters, but the pieces may still be too large to catch as they're cut.
Log cradles can help catch the halves as they're split, so that way you're not continuously bending and lifting the pieces.
This is a good thing, because a quarter of a giant log still needs to be split further.
Working in Double-Time
If you've got a lot of medium-sized logs that need to be split into quarters, you may not want to spend as much time on each one.
To power through many logs in half the time, you can use a 4-way wedge to cut your work load in half. Essentially, it combines the previous two steps into one by incorporating wings on the splitting wedge to cut it into 4 pieces at once.
While this won't necessarily be the way to go with super-sized logs, it'll cut your workload in half with the average sized logs.
Jiashan Superpower Tools Co., Ltd specializes in manufacturing various kinds of Lawn & Garden products and log splitters. Our main items are bg splitter, dump carts, spreaders, lawn sweepers, lawn aerators , etc. Over ten years of manufacturing experience in log splitter industry, we developed more and more innovative log splitter , which are energy-saving and environmentally friendly. We have got a few patents on some of our Log Splitter.Su-perpower has become a leading manufacturer in log splitters in China.
2017年3月25日星期六
A fuel or electric Log Splitter for sale
If you are interested in purchasing a fuel or electric Log Splitter for sale,
it is likely that you are set on finding the best possible one. Unfortunately,
‘best’ will mean different things to different people. Some will believe it
refers to the best selling ones and others will believe it refers to the top
rated ones. So, how can you go about finding the best model for your needs?
The easiest way to determine the current best selling splitters is to simply walk into a showroom and ask one of the sales reps which three models are the most popular.
Determining the top rated splitters will, unfortunately, be a little more difficult. The decision is made based on the features of the machine, so your best bet will be to search online.
The easiest way to determine the models most recommended by the experts is also to search online. You could ask a sales rep, but if they don’t know they might just make it up.
Whilst you should definitely compare each of the lists to see which log splitters continue to reappear, you will probably find that most people are drawn to expert recommendations. This is because someone who is considered highly knowledgeable in the field has deemed that particular model as up to the task and worthy of spending your money on.
When it comes to electric splitters, you will probably find that horizontal models tend to fill up most of the top spots. This is because the force exerted will be able to best cut through the log at this angle.
When it comes to fuel splitters, you will probably find that combination horizontal and vertical models tend to fill up most of the top spots. This is because these machines are much bigger and more versatile.
So, the next time you are looking at either electric or fuel log splitters for sale, make sure you find out what the best selling models are, the top rated models are and the most recommended models are. This should give you a pretty good idea of the brands that are performing the best Black Diamond Log Splitter, allowing you to make a choice that will suit your needs perfectly.
The easiest way to determine the current best selling splitters is to simply walk into a showroom and ask one of the sales reps which three models are the most popular.
Determining the top rated splitters will, unfortunately, be a little more difficult. The decision is made based on the features of the machine, so your best bet will be to search online.
The easiest way to determine the models most recommended by the experts is also to search online. You could ask a sales rep, but if they don’t know they might just make it up.
Whilst you should definitely compare each of the lists to see which log splitters continue to reappear, you will probably find that most people are drawn to expert recommendations. This is because someone who is considered highly knowledgeable in the field has deemed that particular model as up to the task and worthy of spending your money on.
When it comes to electric splitters, you will probably find that horizontal models tend to fill up most of the top spots. This is because the force exerted will be able to best cut through the log at this angle.
When it comes to fuel splitters, you will probably find that combination horizontal and vertical models tend to fill up most of the top spots. This is because these machines are much bigger and more versatile.
So, the next time you are looking at either electric or fuel log splitters for sale, make sure you find out what the best selling models are, the top rated models are and the most recommended models are. This should give you a pretty good idea of the brands that are performing the best Black Diamond Log Splitter, allowing you to make a choice that will suit your needs perfectly.
2017年3月21日星期二
A list of the top 10 best log splitters
Whether you have a wood burning stove or a fire pit, you won’t want to be
without a good Log Splitter. These easy-to-use
pieces of equipment will ensure you get just the right size wood for your fire
each and every time. Besides having one at home, log splitters are great to take
along on any camping adventure or outdoor excursion. The best kinds of log
splitters are safe to use and do not require a lot of maintenance. If you have
been searching for a good one to have, here is a list of the top 10 best log
splitters.
22ton Gas Log Splitter-Full Beam
DESCRIPTION
Average assembly time is under 35 minutes
Accommodates splitting in both horizontal and vertical position
Square log cradle for quicker, easier and safer splitting
Powerful trouble free Kohler Engine
Full beam design
Available with Kohler Engine, LCT Engine and Rato Engine
25ton Gas Log Splitter-Full Beam
DESCRIPTION
Average assembly time is under 35 minutes
Accommodates splitting in both horizontal and vertical position
Square log cradle for quicker, easier and safer splitting
Powerful trouble free Kohler Engine
Full beam design
Available with Kohler Engine, LCT Engine and Rato Engine
30ton Gas Log Splitter-Full Beam
DESCRIPTION
Average assembly time is under 35minutes
Accommodates splitting in both horizontal and vertical position
Square log cradle for quicker, easier and safer splitting
Powerful trouble free Kohler Engine
Full beam design
Available with Kohler Engine, LCT Engine and Rato Engine
37ton Gas Log Splitter-Full Beam
DESCRIPTION
Average assembly time is under 35minutes
Accommodates splitting in both horizontal and vertical position
Square log cradle for quicker, easier and safer splitting
Powerful trouble free Kohler Engine
Full beam design
Available with Kohler Engine, LCT Engine and Rato Engine
30ton Gas Log Splitter-Full Beam
DESCRIPTION
Average assembly time is under 35minutes
Accommodates splitting in both horizontal and vertical position
Square log cradle for quicker, easier and safer splitting
Powerful trouble free B&S Engine
37ton Gas Log Splitter-Full Beam
DESCRIPTION
Average assembly time is under 35minutes
Accommodates splitting in both horizontal and vertical position
Powerful trouble free Kohler Engine
Half beam design
Available with Kohler Engine, LCT Engine and Rato Engine
37ton Gas Log Splitter-Full Beam
DESCRIPTION
Vertical or horizontal operating position lets you work most efficiently in a variety of conditions
Heavy Duty Log Table
50MM hitch included for towing behind vehicles
12ton Gas Log Splitter-Half Beam
DESCRIPTION
Working at horizontal position only
Auto return hydraulic control valve
Heavy duty splitting wedge 6 inches
13ton Gas Log Splitter-Half Beam
DESCRIPTION
Reliable, portable log splitter to handle the tough jobs
Spring loaded push plate return
Patented fast-speed cylinder
10 in. pneumatic tires
Universal pin type
13 second total cycle time
12ton Gas China Log
Splitter-Half Beam
DESCRIPTION
Accommodates splitting in horizontal only
Half beam design
Average assembly time is under 30 minutes
12 Ton max. splitting force
DESCRIPTION
Average assembly time is under 35 minutes
Accommodates splitting in both horizontal and vertical position
Square log cradle for quicker, easier and safer splitting
Powerful trouble free Kohler Engine
Full beam design
Available with Kohler Engine, LCT Engine and Rato Engine
DESCRIPTION
Average assembly time is under 35 minutes
Accommodates splitting in both horizontal and vertical position
Square log cradle for quicker, easier and safer splitting
Powerful trouble free Kohler Engine
Full beam design
Available with Kohler Engine, LCT Engine and Rato Engine
DESCRIPTION
Average assembly time is under 35minutes
Accommodates splitting in both horizontal and vertical position
Square log cradle for quicker, easier and safer splitting
Powerful trouble free Kohler Engine
Full beam design
Available with Kohler Engine, LCT Engine and Rato Engine
DESCRIPTION
Average assembly time is under 35minutes
Accommodates splitting in both horizontal and vertical position
Square log cradle for quicker, easier and safer splitting
Powerful trouble free Kohler Engine
Full beam design
Available with Kohler Engine, LCT Engine and Rato Engine
DESCRIPTION
Average assembly time is under 35minutes
Accommodates splitting in both horizontal and vertical position
Square log cradle for quicker, easier and safer splitting
Powerful trouble free B&S Engine
DESCRIPTION
Average assembly time is under 35minutes
Accommodates splitting in both horizontal and vertical position
Powerful trouble free Kohler Engine
Half beam design
Available with Kohler Engine, LCT Engine and Rato Engine
DESCRIPTION
Vertical or horizontal operating position lets you work most efficiently in a variety of conditions
Heavy Duty Log Table
50MM hitch included for towing behind vehicles
DESCRIPTION
Working at horizontal position only
Auto return hydraulic control valve
Heavy duty splitting wedge 6 inches
DESCRIPTION
Reliable, portable log splitter to handle the tough jobs
Spring loaded push plate return
Patented fast-speed cylinder
10 in. pneumatic tires
Universal pin type
13 second total cycle time
DESCRIPTION
Accommodates splitting in horizontal only
Half beam design
Average assembly time is under 30 minutes
12 Ton max. splitting force
2017年3月19日星期日
What type of hydraulic fluid should I use in my Log Splitter ?
How much and what type of hydraulic fluid should I use in my Log Splitter ?
IMPORTANT! Never operate a log splitter without the appropriate amount of approved hydraulic fluid in the reservoir tank. Operating a log splitter without sufficient reservoir fluid in the hydraulic system may result in severe damage the hydraulic pump and would be reason to void the factory warranty.
DO NOT MIX DIFFERENT TYPES OF HYDRAULIC FLUIDS. Use only one type of an approved lubricant. If the type of fluid already installed in a unit is unknown, the recommended procedure is to drain that fluid completely and refill it with all of the same type fluid.
Our log splitters have varying fluid capacities depending on the model and style. Most units have either a 3.5 gallon, 4 gallon, or 7 gallon reservoir. Please refer to the appropriate product Operator's Manual to determine the capacity of the hydraulic reservoir of a particular model.
The approved fluids that our log splitter hydraulic systems may be filled with are:
Dexron III Automatic Transmission Fluid.
10W AW Hydraulic Oil.
Pro Mix AW-32 Hydraulic Fluid.
These fluids are all non-foaming hydraulic fluids and available from our Online Parts Store, most hardware stores, automotive supply, farm equipment retailers, and other major home improvement supply stores.
Keep in mind that the volume of the reservoir tank is less than the unit's total fluid capacity. Fluid also needs to be primed into the hydraulic system (hoses, filter, valve, pump & cylinder), which may require as much as an extra gallon when filling the complete system.
To prime the hydraulic system, fill the fluid to the appropriate level as instructed in your Operator's Manual. Disconnect the spark plug wire and ground it against the engine. Then pull the starter rope on the engine 10 to 15 times. This will allow the pump to push fluid into these other areas of the hydraulic system. Your reservoir level should go down, so you will need to re-check it and fill to the appropriate level.
Before splitting any wood, you should extend and retract the wedge at least 12 cycles* to remove any trapped air in the system. Again, check and fill reservoir log splitter for sale .
IMPORTANT! Never operate a log splitter without the appropriate amount of approved hydraulic fluid in the reservoir tank. Operating a log splitter without sufficient reservoir fluid in the hydraulic system may result in severe damage the hydraulic pump and would be reason to void the factory warranty.
DO NOT MIX DIFFERENT TYPES OF HYDRAULIC FLUIDS. Use only one type of an approved lubricant. If the type of fluid already installed in a unit is unknown, the recommended procedure is to drain that fluid completely and refill it with all of the same type fluid.
Our log splitters have varying fluid capacities depending on the model and style. Most units have either a 3.5 gallon, 4 gallon, or 7 gallon reservoir. Please refer to the appropriate product Operator's Manual to determine the capacity of the hydraulic reservoir of a particular model.
The approved fluids that our log splitter hydraulic systems may be filled with are:
Dexron III Automatic Transmission Fluid.
10W AW Hydraulic Oil.
Pro Mix AW-32 Hydraulic Fluid.
These fluids are all non-foaming hydraulic fluids and available from our Online Parts Store, most hardware stores, automotive supply, farm equipment retailers, and other major home improvement supply stores.
Keep in mind that the volume of the reservoir tank is less than the unit's total fluid capacity. Fluid also needs to be primed into the hydraulic system (hoses, filter, valve, pump & cylinder), which may require as much as an extra gallon when filling the complete system.
To prime the hydraulic system, fill the fluid to the appropriate level as instructed in your Operator's Manual. Disconnect the spark plug wire and ground it against the engine. Then pull the starter rope on the engine 10 to 15 times. This will allow the pump to push fluid into these other areas of the hydraulic system. Your reservoir level should go down, so you will need to re-check it and fill to the appropriate level.
Before splitting any wood, you should extend and retract the wedge at least 12 cycles* to remove any trapped air in the system. Again, check and fill reservoir log splitter for sale .
2017年3月15日星期三
Gas or Electric Powered Log Splitter?
Gas or Electric Powered Log Splitter?
Home users may opt for a manual or small electric log splitter for preparing firewood from larger logs of wood.
However, if you need a powerful splitter to cut larger logs, then the gas powered model could well be perfect for you. If you anticipate only using a log splitter once, hiring one to save costs is a worthwhile option.
After finding the right splitter, it’s time to cut some logs.
Let’s start splittin’ some wood!
Place the log against the endplate. When positioning the log, make sure it goes against the wood’s grain.
Keep the log steady by placing your left hand on the side of the log opposite of the beam. Never, ever, ever put your hand at the end of the log, or between the log and the endplate. (Common sense, but we have to mention it.)
Move the control handle to the Forward position and watch the wedge do all the work. Go wedge go.
As soon as the wedge contacts the log, immediately remove your left hand and continue to hold the control handle in the Forward position.
Release the control handle to stop the wedge.
Move the control handle to the Reverse position and return the wedge to its starting position.
If for any reason the wedge only partially splits the wood or becomes stuck, immediately move the control handle to the Reverse position. Then, move the control handle back to the Forward position. This should allow the wedge to gain momentum and push through the log – like a running back picking up steam before hitting the hole.
*Caution: never try and remove a partially split log with your hands. Wedges show fingers no mercy.
Log Splitter : http://www.cnsuperpower.com/product/log-splitter/
Home users may opt for a manual or small electric log splitter for preparing firewood from larger logs of wood.
However, if you need a powerful splitter to cut larger logs, then the gas powered model could well be perfect for you. If you anticipate only using a log splitter once, hiring one to save costs is a worthwhile option.
After finding the right splitter, it’s time to cut some logs.
Let’s start splittin’ some wood!
Place the log against the endplate. When positioning the log, make sure it goes against the wood’s grain.
Keep the log steady by placing your left hand on the side of the log opposite of the beam. Never, ever, ever put your hand at the end of the log, or between the log and the endplate. (Common sense, but we have to mention it.)
Move the control handle to the Forward position and watch the wedge do all the work. Go wedge go.
As soon as the wedge contacts the log, immediately remove your left hand and continue to hold the control handle in the Forward position.
Release the control handle to stop the wedge.
Move the control handle to the Reverse position and return the wedge to its starting position.
If for any reason the wedge only partially splits the wood or becomes stuck, immediately move the control handle to the Reverse position. Then, move the control handle back to the Forward position. This should allow the wedge to gain momentum and push through the log – like a running back picking up steam before hitting the hole.
*Caution: never try and remove a partially split log with your hands. Wedges show fingers no mercy.
Log Splitter : http://www.cnsuperpower.com/product/log-splitter/
2017年3月14日星期二
CNsuperpower Log Splitter require careful thought before purchasing
Considering that it is a heavy-duty piece of machinery, Log Splitter
require careful thought before purchasing. We need to know how to use
it in order to help us do better work. Once again, it greatly depends on
the tree that you are trying to cut down, based on its size and
thickness. Therefore, here are some aspects to look into while looking
around:
1. Maximum Load
Also known as the “ability” or “capacity” load, knowing just how much a log splitter can take in terms of the number of logs that it can slice through at once. Especially if you tend to have a lot of logs that require to be cut, then going with a hefty one will work the best. As a rule of thumb, the heavier the machine is, the more it can go through.
2. Being Portable
Portable - convenient handle and never-flat tires. What's the best log splitter on the market for homeowners? At the same time, you do not want your log splitter to be so heavy that it is virtually impossible to carry it around with you. Particularly if you tend to move from place to place when cutting down trees and splitting logs, having easy-to-manage machinery will be more convenient in the long run. Plus, it saves you the hassle and the energy needed for other activities!
3. Power And Speed
Similar to 1, a log splitter must not only be strong enough to slice through thick and/or numerous log parts, but also be able to handle different wood types. Some kinds of wood, especially from older trees, tend to be tougher to cut through, as the same goes for wet wood. That said, look into the horsepower of your log splitter and see just how much it can take.
At the same time, check out the speed at which the machine can go up to. Normally, a log splitter with a cycle of fifteen seconds is considered fast, quick 20 second cycle time and auto-return control valve and so having a quick, consistent flow when turned on will make for a smooth, stable cut through even the thickest of log parts.
4. Adjustability
Besides considering the thickness of your logs and how much the machine can take in terms of that, looking into the lengths of these materials is also important. Hence, it is necessary to find a log splitter which can adjust to different heights depending on the size of them. From short to long, having an adjustable height, along with clamps to secure them, is the way to go.
5. Type Of Splitter
Just like with pruning saws, log splitters also have different types depending on costs and needs. While electric ones tend to be the most popular, gas and manual ones also exist:
Electric
Commonly used by many gardeners, this particular log splitter runs on electricity, which can then be used either indoors or outdoors. As a result, there are no fumes that can be dangerous to the environment (or to your health) and are affordable.
Electric log splitters and wood splitters are powered by an electrical cord, as opposed to manual or gas log splitters.
Gas
Gas log splitters and wood splitters are powered by gas or petrol with a cc engine, as opposed to manual or electrical corded log splitters.
Manual
Manual splitters have advantages and disadvantages that you should consider. One of the primary advantages of a manual splitter is the cost; with these firewood splitters being the most affordable models. You can purchase a manual splitters in one of two designs which are either vertical or horizontal which will provide up to 10 tons of splitting capacity which is typically powered by a two speed pump. This type of firewood processor is typically slower to load and will also be somewhat more physically demanding then the other two types of models available.
6. Durability
Granted, you probably do not want a log splitter that stops working after the second use: finding a good piece of machinery that can last you a long time can be difficult, but a good rule of thumb is to look for those which are made from steel. It is known to be very solid, able to withstand just about any blow or force to it, which makes for an ideal type of machinery to own.
7. Comfort
Although you will definitely be investing a lot of time and energy into cutting down wood, having a log splitter that is comfortable enough to handle will make life a lot easier. It is the little things such as cushioned handles to grip when operating that can be a better endeavor than if they were not to exist.
Shop our selection of log splitters in the outdoors department Performance Built Log Splitter at cnsuperpower.com.
1. Maximum Load
Also known as the “ability” or “capacity” load, knowing just how much a log splitter can take in terms of the number of logs that it can slice through at once. Especially if you tend to have a lot of logs that require to be cut, then going with a hefty one will work the best. As a rule of thumb, the heavier the machine is, the more it can go through.
2. Being Portable
Portable - convenient handle and never-flat tires. What's the best log splitter on the market for homeowners? At the same time, you do not want your log splitter to be so heavy that it is virtually impossible to carry it around with you. Particularly if you tend to move from place to place when cutting down trees and splitting logs, having easy-to-manage machinery will be more convenient in the long run. Plus, it saves you the hassle and the energy needed for other activities!
3. Power And Speed
Similar to 1, a log splitter must not only be strong enough to slice through thick and/or numerous log parts, but also be able to handle different wood types. Some kinds of wood, especially from older trees, tend to be tougher to cut through, as the same goes for wet wood. That said, look into the horsepower of your log splitter and see just how much it can take.
At the same time, check out the speed at which the machine can go up to. Normally, a log splitter with a cycle of fifteen seconds is considered fast, quick 20 second cycle time and auto-return control valve and so having a quick, consistent flow when turned on will make for a smooth, stable cut through even the thickest of log parts.
4. Adjustability
Besides considering the thickness of your logs and how much the machine can take in terms of that, looking into the lengths of these materials is also important. Hence, it is necessary to find a log splitter which can adjust to different heights depending on the size of them. From short to long, having an adjustable height, along with clamps to secure them, is the way to go.
5. Type Of Splitter
Just like with pruning saws, log splitters also have different types depending on costs and needs. While electric ones tend to be the most popular, gas and manual ones also exist:
Electric
Commonly used by many gardeners, this particular log splitter runs on electricity, which can then be used either indoors or outdoors. As a result, there are no fumes that can be dangerous to the environment (or to your health) and are affordable.
Electric log splitters and wood splitters are powered by an electrical cord, as opposed to manual or gas log splitters.
Gas
Gas log splitters and wood splitters are powered by gas or petrol with a cc engine, as opposed to manual or electrical corded log splitters.
Manual
Manual splitters have advantages and disadvantages that you should consider. One of the primary advantages of a manual splitter is the cost; with these firewood splitters being the most affordable models. You can purchase a manual splitters in one of two designs which are either vertical or horizontal which will provide up to 10 tons of splitting capacity which is typically powered by a two speed pump. This type of firewood processor is typically slower to load and will also be somewhat more physically demanding then the other two types of models available.
6. Durability
Granted, you probably do not want a log splitter that stops working after the second use: finding a good piece of machinery that can last you a long time can be difficult, but a good rule of thumb is to look for those which are made from steel. It is known to be very solid, able to withstand just about any blow or force to it, which makes for an ideal type of machinery to own.
7. Comfort
Although you will definitely be investing a lot of time and energy into cutting down wood, having a log splitter that is comfortable enough to handle will make life a lot easier. It is the little things such as cushioned handles to grip when operating that can be a better endeavor than if they were not to exist.
Shop our selection of log splitters in the outdoors department Performance Built Log Splitter at cnsuperpower.com.
2017年3月12日星期日
Log Splitter require careful thought before purchasing
Considering that it is a heavy-duty piece of machinery, Log Splitter
require careful thought before purchasing. Once again, it greatly
depends on the tree that you are trying to cut down, based on its size
and thickness. Therefore, here are some aspects to look into while
looking around:
#1. Maximum Load
Also known as the “ability” or “capacity” load, knowing just how much a log splitter can take in terms of the number of logs that it can slice through at once. Especially if you tend to have a lot of logs that require to be cut, then going with a hefty one will work the best. As a rule of thumb, the heavier the machine is, the more it can go through.
#2. Being Portable
At the same time, you do not want your log splitter to be so heavy that it is virtually impossible to carry it around with you. Particularly if you tend to move from place to place when cutting down trees and splitting logs, having easy-to-manage machinery will be more convenient in the long run. Plus, it saves you the hassle and the energy needed for other activities!
#3. Power And Speed
Similar to #1, a log splitter must not only be strong enough to slice through thick and/or numerous log parts, but also be able to handle different wood types. Some kinds of wood, especially from older trees, tend to be tougher to cut through, as the same goes for wet wood. That said, look into the horsepower of your log splitter and see just how much it can take.
At the same time, check out the speed at which the machine can go up to. Normally, a log splitter with a cycle of fifteen seconds is considered fast, and so having a quick, consistent flow when turned on will make for a smooth, stable cut through even the thickest of log parts.
#4. Adjustability
Besides considering the thickness of your logs and how much the machine can take in terms of that, looking into the lengths of these materials is also important. Hence, it is necessary to find a log splitter which can adjust to different heights depending on the size of them. From short to long, having an adjustable height, along with clamps to secure them, is the way to go.
#5. Type Of Splitter
Just like with pruning saws, log splitters also have different types depending on costs and needs. While electric ones tend to be the most popular, gas and manual ones also exist:
1
Electric
Commonly used by many gardeners, this particular log splitter runs on electricity, which can then be used either indoors or outdoors. As a result, there are no fumes that can be dangerous to the environment (or to your health) and are affordable.
Only thing is to make sure that it does not get short circuit, or that the electrical outlets are not down for you to use it.
2
Gas
While it is heavy and it emits tons of fumes, the gas log splitter is the best when it comes to chopping thick or numerous log pieces. Granted, it might be difficult to manage, but once you get the hang of it, it will work like a charm.
3
Manual
Good for the budget, manual log splitters allow you to control their speed with a two-speed pump system, and they are easy to adjust, as well as being lightweight. At the same time, however, they take more time to chop things down, so it helps to have patience when using this particular log splitter.
#6. Durability
Granted, you probably do not want a log splitter that stops working after the second use: finding a good piece of machinery that can last you a long time can be difficult, but a good rule of thumb is to look for those which are made from steel. It is known to be very solid, able to withstand just about any blow or force to it, which makes for an ideal type of machinery to own.
#7. Comfort
Although you will definitely be investing a lot of time and energy into cutting down wood, having a Black Diamond Log Splitter that is comfortable enough to handle will make life a lot easier. It is the little things such as cushioned handles to grip when operating that can be a better endeavor than if they were not to exist.
#1. Maximum Load
Also known as the “ability” or “capacity” load, knowing just how much a log splitter can take in terms of the number of logs that it can slice through at once. Especially if you tend to have a lot of logs that require to be cut, then going with a hefty one will work the best. As a rule of thumb, the heavier the machine is, the more it can go through.
#2. Being Portable
At the same time, you do not want your log splitter to be so heavy that it is virtually impossible to carry it around with you. Particularly if you tend to move from place to place when cutting down trees and splitting logs, having easy-to-manage machinery will be more convenient in the long run. Plus, it saves you the hassle and the energy needed for other activities!
#3. Power And Speed
Similar to #1, a log splitter must not only be strong enough to slice through thick and/or numerous log parts, but also be able to handle different wood types. Some kinds of wood, especially from older trees, tend to be tougher to cut through, as the same goes for wet wood. That said, look into the horsepower of your log splitter and see just how much it can take.
At the same time, check out the speed at which the machine can go up to. Normally, a log splitter with a cycle of fifteen seconds is considered fast, and so having a quick, consistent flow when turned on will make for a smooth, stable cut through even the thickest of log parts.
#4. Adjustability
Besides considering the thickness of your logs and how much the machine can take in terms of that, looking into the lengths of these materials is also important. Hence, it is necessary to find a log splitter which can adjust to different heights depending on the size of them. From short to long, having an adjustable height, along with clamps to secure them, is the way to go.
#5. Type Of Splitter
Just like with pruning saws, log splitters also have different types depending on costs and needs. While electric ones tend to be the most popular, gas and manual ones also exist:
1
Electric
Commonly used by many gardeners, this particular log splitter runs on electricity, which can then be used either indoors or outdoors. As a result, there are no fumes that can be dangerous to the environment (or to your health) and are affordable.
Only thing is to make sure that it does not get short circuit, or that the electrical outlets are not down for you to use it.
2
Gas
While it is heavy and it emits tons of fumes, the gas log splitter is the best when it comes to chopping thick or numerous log pieces. Granted, it might be difficult to manage, but once you get the hang of it, it will work like a charm.
3
Manual
Good for the budget, manual log splitters allow you to control their speed with a two-speed pump system, and they are easy to adjust, as well as being lightweight. At the same time, however, they take more time to chop things down, so it helps to have patience when using this particular log splitter.
#6. Durability
Granted, you probably do not want a log splitter that stops working after the second use: finding a good piece of machinery that can last you a long time can be difficult, but a good rule of thumb is to look for those which are made from steel. It is known to be very solid, able to withstand just about any blow or force to it, which makes for an ideal type of machinery to own.
#7. Comfort
Although you will definitely be investing a lot of time and energy into cutting down wood, having a Black Diamond Log Splitter that is comfortable enough to handle will make life a lot easier. It is the little things such as cushioned handles to grip when operating that can be a better endeavor than if they were not to exist.
2017年3月10日星期五
What makes a good electric log splitter?
Electric log splitters are generally seen as the ‘mid-range’ of the log splitter family, offering far more convenience then a manual, but without the heavy hitting power of the larger gas powered log splitters. That said, the difference between a poor quality electric Log Splitter and the top range ones is immense, and price tag alone isn’t always enough to tell you which you’re buying. So we’ve rounded up the best of the best electric log splitters on the market for you.
What makes a good electric log splitter?
Most electric log splitters will work happily from the standard electricity of the average suburban home. They also have the distinct advantage of being fume free- making them safe to operate in tighter spaces then gas powered log splitters. If you’re looking for a high quality unit, but don’t want to face the hefty outlay of a gas-powered log splitter, this is the type for you.
While they often don’t quite have the ramming force of their larger cousins, and the cycle time will usually be significantly slower, this is usually a moot point as they will far outstrip the working speed of the average single person. They’re a great choice for the user who will not be using the electrical log splitter day in and day out, but rather want a portable and manoeuvrable unit that can be stored conveniently. They will boost your working speed and make your log splitting endeavours much more smooth and free of backbreaking manual labour without breaking the bank.
What makes a good electrical log splitter?
A robust design is essential in any log splitter, especially if you want to get many years of use from your investment. All steel casing is usually a good plan. You should also look for a design in which the engine is tucked away from the working area, for your convenience.
A log cradle to prevent spillages, and making sure that the unit is fit for the type and size of Forest King Log Splitter you typically will need to cut is a great plan too. Don’t fuss too much over cycle times if you don’t need the unit to work in a commercial environment, and make sure you opt for a unit with a quality wedge that can handle loads and will be easy to replace when the time comes.
What makes a good electric log splitter?
Most electric log splitters will work happily from the standard electricity of the average suburban home. They also have the distinct advantage of being fume free- making them safe to operate in tighter spaces then gas powered log splitters. If you’re looking for a high quality unit, but don’t want to face the hefty outlay of a gas-powered log splitter, this is the type for you.
While they often don’t quite have the ramming force of their larger cousins, and the cycle time will usually be significantly slower, this is usually a moot point as they will far outstrip the working speed of the average single person. They’re a great choice for the user who will not be using the electrical log splitter day in and day out, but rather want a portable and manoeuvrable unit that can be stored conveniently. They will boost your working speed and make your log splitting endeavours much more smooth and free of backbreaking manual labour without breaking the bank.
What makes a good electrical log splitter?
A robust design is essential in any log splitter, especially if you want to get many years of use from your investment. All steel casing is usually a good plan. You should also look for a design in which the engine is tucked away from the working area, for your convenience.
A log cradle to prevent spillages, and making sure that the unit is fit for the type and size of Forest King Log Splitter you typically will need to cut is a great plan too. Don’t fuss too much over cycle times if you don’t need the unit to work in a commercial environment, and make sure you opt for a unit with a quality wedge that can handle loads and will be easy to replace when the time comes.
2017年3月9日星期四
To finding the perfect Lumber Jack Log Splitter
Making your own firewood for fuel is a very satisfying task, especially if
the wood is coming from trees on your farm, but splitting the logs by hand can
be tricky and tiresome. Fortunately, there are machines that can do the work for
you, speeding up the process and enabling you to split more wood with less
effort.
Log Splitter is a great tool, but come in many different sizes and have a wide variety of specifications to consider. To help you sort through all the options, here’s a guide to the key features and things to consider when shopping.
Electric Or Gas?
Log splitters are usually powered by electricity or gas, with each source of power offering advantages and disadvantages. It’s hard to beat the simplicity of electricity—plug it in and you’re good to go and free from the exhaust of a gasoline engine, meaning that you can split logs in a building if you desire.
However, many electric log splitters aren’t nearly as strong as ones powered by gasoline engines, so for large, tough logs that are difficult to split, a powerful gasoline splitter is the way to go. Although they are heavier, more difficult to move around and require the typical maintenance of any small engine, gasoline log splitters carry their power with them and don’t have to be used near an electrical outlet—if you’ve got a log pile on the edge of your property, far from your buildings, you can take your log splitter to the pile rather than the other way around. Many gasoline log splitters are even designed to be towed by vehicles, a bonus if you need to frequently transport it across your farm.
How Much Strength?
Log splitters come in many different sizes and strengths, and price tags vary based on these factors, so knowing how much power you need will help you save money. If you’re looking to split only a few small logs a year to provide fuel for outdoor grills or campfires, a small electric log splitter might be perfect for you. In contrast, if you’re heating your home with wood and need to produce many cords of split wood for a long winter, investing in a larger, faster and more powerful splitter can help the job go much easier.
The strength of log splitters is measured in tons. Small electric splitters might produce from 5 to 7 tons of force, while larger electric and gasoline splitters are much stronger—20 tons or more of force is common, with many generating more than 30 or 35 tons.
The type of logs that you’ll be splitting is the main consideration when choosing the strength of your splitter. Generally, coniferous trees, like pines and spruces, have soft wood that splits easily; deciduous trees, like maples and oaks, have much harder wood that requires more power to split.
The diameter of the logs is also important: The thicker the log, the harder it is to split. You might discover that a machine capable of splitting a maple log with a 6-inch diameter might not be able to split a maple log that’s 15 inches thick.
How Long is the Cycle Time?
The cycle time of a log splitter measures the time it takes for the machine to split a log and get back in position to split another. Depending on the model, cycle time can vary from around 10 to 20 seconds, so if you’re planning to split dozens or even hundreds of logs, opting for a splitter with a shorter cycle time can save you a lot of time in the long run.
Other Features to Consider
For gasoline log splitters, the capacity of the fuel tank is something to consider if you’re planning on splitting lots of logs far from a gas supply. Their small engines can run for a long time on surprisingly little fuel, but a splitter that can hold 1½ gallons of gas will run longer than one with a 1/2-gallon tank.
The orientation of the splitting process also varies. Some models require you to place the log horizontally across the top of the splitter, while others are upright and require you to place the log vertically against the splitter. Some units are adaptable and can do both, depending on your preference.
It’s also important to keep in mind that log splitters can’t split a log of any length; they all have a maximum log length that they can handle, because logs of any greater length would not physically fit in the splitter. A larger splitter that can handle longer logs—say, 25 inches—means that you won’t need to cut large logs into as many small pieces as you would if using a splitter with a 20-inch maximum length.
By evaluating the number and type of logs that you’re planning to split, and analyzing the key features of available log splitters, you should be well on your way to finding the perfect Lumber Jack Log Splitter that can serve you well for years to come!
Log Splitter is a great tool, but come in many different sizes and have a wide variety of specifications to consider. To help you sort through all the options, here’s a guide to the key features and things to consider when shopping.
Electric Or Gas?
Log splitters are usually powered by electricity or gas, with each source of power offering advantages and disadvantages. It’s hard to beat the simplicity of electricity—plug it in and you’re good to go and free from the exhaust of a gasoline engine, meaning that you can split logs in a building if you desire.
However, many electric log splitters aren’t nearly as strong as ones powered by gasoline engines, so for large, tough logs that are difficult to split, a powerful gasoline splitter is the way to go. Although they are heavier, more difficult to move around and require the typical maintenance of any small engine, gasoline log splitters carry their power with them and don’t have to be used near an electrical outlet—if you’ve got a log pile on the edge of your property, far from your buildings, you can take your log splitter to the pile rather than the other way around. Many gasoline log splitters are even designed to be towed by vehicles, a bonus if you need to frequently transport it across your farm.
How Much Strength?
Log splitters come in many different sizes and strengths, and price tags vary based on these factors, so knowing how much power you need will help you save money. If you’re looking to split only a few small logs a year to provide fuel for outdoor grills or campfires, a small electric log splitter might be perfect for you. In contrast, if you’re heating your home with wood and need to produce many cords of split wood for a long winter, investing in a larger, faster and more powerful splitter can help the job go much easier.
The strength of log splitters is measured in tons. Small electric splitters might produce from 5 to 7 tons of force, while larger electric and gasoline splitters are much stronger—20 tons or more of force is common, with many generating more than 30 or 35 tons.
The type of logs that you’ll be splitting is the main consideration when choosing the strength of your splitter. Generally, coniferous trees, like pines and spruces, have soft wood that splits easily; deciduous trees, like maples and oaks, have much harder wood that requires more power to split.
The diameter of the logs is also important: The thicker the log, the harder it is to split. You might discover that a machine capable of splitting a maple log with a 6-inch diameter might not be able to split a maple log that’s 15 inches thick.
How Long is the Cycle Time?
The cycle time of a log splitter measures the time it takes for the machine to split a log and get back in position to split another. Depending on the model, cycle time can vary from around 10 to 20 seconds, so if you’re planning to split dozens or even hundreds of logs, opting for a splitter with a shorter cycle time can save you a lot of time in the long run.
Other Features to Consider
For gasoline log splitters, the capacity of the fuel tank is something to consider if you’re planning on splitting lots of logs far from a gas supply. Their small engines can run for a long time on surprisingly little fuel, but a splitter that can hold 1½ gallons of gas will run longer than one with a 1/2-gallon tank.
The orientation of the splitting process also varies. Some models require you to place the log horizontally across the top of the splitter, while others are upright and require you to place the log vertically against the splitter. Some units are adaptable and can do both, depending on your preference.
It’s also important to keep in mind that log splitters can’t split a log of any length; they all have a maximum log length that they can handle, because logs of any greater length would not physically fit in the splitter. A larger splitter that can handle longer logs—say, 25 inches—means that you won’t need to cut large logs into as many small pieces as you would if using a splitter with a 20-inch maximum length.
By evaluating the number and type of logs that you’re planning to split, and analyzing the key features of available log splitters, you should be well on your way to finding the perfect Lumber Jack Log Splitter that can serve you well for years to come!
2 Kinetic Log Splitters on CNSuperpower
Kinetic ram force to split logs fast and easy. Includes 3 year Kohler
warranty on all parts and labor, worktable, removable hitch, all terrain tires
on chrome rims, expansion splitter wedge, case hardened ram. Kinetic flywheel
splitter design eliminates the hoses, pumps, valves, cylinders, filters and
couplers used on hydraulic splitters. This machine is built for Su-perpower and
3 SEC RAM speed. A serious new breed of Su-perpower Kinetic
Log Splitter that out splits hydraulic splitters 6 to 1.
T20 Kinetic Log Splitter is designed to provide years of trouble free splitting.
• Patented clutch system allows constant rack engagement
• Clutch allows maximum power at safe rack speed
• Designed to prevent kickback when rack is disengaged
Kinetic Log Splitter
T30 Kinetic Log Splitter is designed to provide years of trouble free splitting
• Patented clutch system allows constant rack engagement
• Clutch system operates at safer rack speed for maximum output
• Designed to prevent kickback when rack is disengaged
CNSuperpower Log Splitters provides a full range of log splitters from home, cottage and industrial use.
T20 Kinetic Log Splitter is designed to provide years of trouble free splitting.
• Patented clutch system allows constant rack engagement
• Clutch allows maximum power at safe rack speed
• Designed to prevent kickback when rack is disengaged
T30 Kinetic Log Splitter is designed to provide years of trouble free splitting
• Patented clutch system allows constant rack engagement
• Clutch system operates at safer rack speed for maximum output
• Designed to prevent kickback when rack is disengaged
CNSuperpower Log Splitters provides a full range of log splitters from home, cottage and industrial use.
2017年3月5日星期日
Which Type of Log Splitter is the Best Exclusive Deals
Which type of log splitter is the best for me? Exclusive deals - Log Splitter - cnsuperpower !
Depending on what you charge from a log splitter, you can accept from 5 altered types. They all accomplish on the aforementioned basal premise- instead of application speed, they use force to breach the wood, gradually active a block into the log.
The a lot of basal type is the chiral log splitter, which uses you as a adeptness source, so it’s just hardly bigger from application an axe- it’s added able and faster than application an axe, but it’s still backbreaking and it’s boilerplate abreast abundant to powered log splitters if it comes to performance.
Next three types are all hydraulic log splitters, the capital aberration amid them getting their adeptness source- capital two getting electric and gas powered, and third uses your car as a adeptness source. They use altered adeptness sources to ammunition the aforementioned mechanism- hydraulic pump which drives the ram that splits the wood.
Electric log splitters are the best best for a lot of homeowners, aback they accept abundant backbone to administer boilerplate sized logs, and affordable prices, and use of electric adeptness makes their use applied and economical.
Gas-powered log splitters are added able than added hydraulic log-splitter, which makes them added acceptable for agreeable tougher and harder logs, or amounts of copse that are bigger than the average, aback their added adeptness aswell makes them faster. However, the gas acclimated for active these log splitters isn’t the cheapest option, and it aswell makes alive with them added unpleasant, due to gas emissions and babble they produce.
Machine army log splitters are mainly acclimated with tractors, and aback they use the car as the adeptness source, they can be absolutely powerful, but due to specific altitude in which they adeptness be useful, they aren’t as popular.
Last blazon are active log splitters, which don’t use hydraulic pump but active technology and motion, which makes for stunningly fast and able results. These log splitters are acclimated for able log splitting, due to the massive amounts of altered blazon of wood, which makes it all-important to use a Log Splitter this fast.
Depending on what you charge from a log splitter, you can accept from 5 altered types. They all accomplish on the aforementioned basal premise- instead of application speed, they use force to breach the wood, gradually active a block into the log.
The a lot of basal type is the chiral log splitter, which uses you as a adeptness source, so it’s just hardly bigger from application an axe- it’s added able and faster than application an axe, but it’s still backbreaking and it’s boilerplate abreast abundant to powered log splitters if it comes to performance.
Next three types are all hydraulic log splitters, the capital aberration amid them getting their adeptness source- capital two getting electric and gas powered, and third uses your car as a adeptness source. They use altered adeptness sources to ammunition the aforementioned mechanism- hydraulic pump which drives the ram that splits the wood.
Electric log splitters are the best best for a lot of homeowners, aback they accept abundant backbone to administer boilerplate sized logs, and affordable prices, and use of electric adeptness makes their use applied and economical.
Gas-powered log splitters are added able than added hydraulic log-splitter, which makes them added acceptable for agreeable tougher and harder logs, or amounts of copse that are bigger than the average, aback their added adeptness aswell makes them faster. However, the gas acclimated for active these log splitters isn’t the cheapest option, and it aswell makes alive with them added unpleasant, due to gas emissions and babble they produce.
Machine army log splitters are mainly acclimated with tractors, and aback they use the car as the adeptness source, they can be absolutely powerful, but due to specific altitude in which they adeptness be useful, they aren’t as popular.
Last blazon are active log splitters, which don’t use hydraulic pump but active technology and motion, which makes for stunningly fast and able results. These log splitters are acclimated for able log splitting, due to the massive amounts of altered blazon of wood, which makes it all-important to use a Log Splitter this fast.
订阅：
博文 (Atom)